Prevost Recalls 2009-2011 Volvo 9700 Motor Coaches for Wiring Defect
Prevost is recalling 185 Volvo 9700 motor coaches due to loose fuse box nuts that may cause engine stalling or fire.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a structural vehicle defect (loose electrical connections) that may lead to a fire, meeting the criteria for a Severe rating.
Plain-English summary
Prevost Cars, Inc. is recalling certain model year 2009-2011 Volvo 9700 motor coaches manufactured between October 31, 2008, and July 1, 2011. The recall involves 185 vehicles.
On some vehicles, there is a possibility of poorly tightened nuts on the front and rear fuse box connections. This defect could cause interruptions in the electrical supply, leading to the engine stalling without warning. Additionally, the loose connections may create excessive heat, which may lead to a fire.
Dealers will inspect the fuse box and perform necessary repairs free of charge. The safety recall began on July 25, 2011. Owners may contact Prevost Car Inc., Service Department at 1-866-870-2046 or 1-418-831-5432.
The recalled product
- Product
- VOLVO BUS 9700
- Brand
- VOLVO BUS
- Manufacturer
- PREVOST CARS, INC.
- Category
- Vehicle — Motor Coach
- Hazard
- Affected units
- 185
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (1)
- 9700
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · VOLVO BUS
- HighVolvo Bus 9700 Recall for Missing Emergency Exit Instructions
NHTSA · 2026-09-18
- SevereVolvo Bus Recalls 2023-2025 9700 Models Due to Fire Suppression Defect
NHTSA · 2025-07-16
- HighVolvo Bus Recalls 2025 9700 Models for Emergency Exit Label Defect
NHTSA · 2024-11-26
- HighVolvo Bus 9700 Recall for Steering Gear Link Rod Nut Tightening
NHTSA · 2024-07-09
- SevereVolvo Bus 9700 Recalled for Potential Steering Link Rod Detachment
NHTSA · 2024-02-08
Same manufacturer · PREVOST CARS, INC.
See all →- SeverePrevost Recalls 2021-2022 X3-45 Commuter Buses for Seat Belt Defect
NHTSA · 2021-06-28
- HighPrevost Recalls 2021 X3 Commuter Buses Due to Parking Brake Defect
NHTSA · 2021-06-28
- High
- SeverePrevost Recalls 2020 Coach Buses Due to Driveshaft Bolt Tightening Issue
NHTSA · 2019-12-17
- HighPrevost Recalls 2020 Coaches Due to Dash Brightness Control Defect
NHTSA · 2019-10-29
Same hazard · fire
See all →- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
- SevereAlliance RV Recalls Valor and Delta Trailers Due to Fire Risk
NHTSA · 2026-10-16
- Severe3M Recalls Scotch Thermal Laminators Due to Fire Hazard
CPSC · 2026-10-15
- SevereToyota Recalls Land Cruiser Hybrid Vehicles for Fuel Leak Risk
NHTSA · 2026-10-14
- SevereIntellijoint Navigation Systems Recalled for Potential Fire Risk
FDA (Devices) · 2026-10-14
Similar recalls
- SeverePrevost Recalls 2009-2013 Volvo Bus 9700 Coaches for Fire Risk
NHTSA · 2012-09-13
- SeverePrevost Recalls 2009-2012 Volvo 9700 Motor Coaches Due to Software Error
NHTSA · 2012-06-26
- HighVolvo Bus 9700 Recalled for Insufficient Emergency Exit Windows
NHTSA · 2012-05-08
- SevereVolvo Bus 9700 Recall: Loose Power Cable Hardware May Cause Overheating
NHTSA · 2017-12-28
- SevereVolvo Bus 9700 Recall: Exhaust Clamp Failure May Cause Fire
NHTSA · 2015-09-28
- HighVolvo Bus 9700 Recalled for Wheelchair Lift Safety Pin Defects
NHTSA · 2012-11-15