Navistar Recalls International ProStar and Lonestar Trucks for Electrical Fire Risk
Navistar is recalling 2009-2015 International ProStar and Lonestar trucks because an undersized electrical harness may overheat and cause a vehicle fire.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a vehicle electrical defect that could cause a vehicle fire, which aligns with the rubric criterion for 'significant injury/property-damage reports' or structural/functional defects posing severe risk.
Plain-English summary
Navistar, Inc. is recalling certain model year 2009-2015 International ProStar and 2010-2015 International Lonestar vehicles. The affected vehicles were manufactured between December 16, 2008, and June 20, 2014, for ProStars, and between October 12, 2009, and June 16, 2014, for Lonestars.
The recall addresses an electrical harness that supplies power to the HVAC system. In the affected vehicles, this harness may not be of sufficient size for the electrical load of the circuit. This condition can result in an increase in resistance and heating at the connectors, which could cause a vehicle fire.
Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. The recall began on March 2, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- INTERNATIONAL PROSTAR, LONESTAR
- Brand
- INTERNATIONAL
- Manufacturer
- Navistar, Inc.
- Category
- Vehicle — Commercial Truck
- Hazard
- Affected units
- 18,798
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (2)
- PROSTAR
- LONESTAR
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · INTERNATIONAL
- HighInternational Recalls 2027 Trucks Due to Wiper Nut Loosening Risk
NHTSA · 2026-08-06
- Severe2023–2027 International MV and HV vehicles battery cable fire risk
NHTSA · 2026-07-16
- SevereInternational Recalls 2026-2027 HV Trucks for Brake Release Delay
NHTSA · 2026-06-11
- SevereInternational Recalls 2026-2027 HV Trucks for Brake Release Delay
NHTSA · 2026-05-11
- HighInternational truck software may fail to brake with adaptive cruise
NHTSA · 2026-02-12
Same manufacturer · Navistar, Inc.
See all →- SevereSchool buses recalled for brake caliper mounting bolt defect
NHTSA · 2024-10-02
- High
- HighNavistar Recalls 2025 International CV Vehicles Due to Inactive Air Bags
NHTSA · 2024-10-01
- Severe
- SevereInternational truck tie rod ball studs were incorrectly heat treated
NHTSA · 2024-06-20
Same hazard · fire
See all →- SevereVQQQ Gas Patio Heaters Recalled for Fire and Burn Hazards
CPSC · 2026-10-22
- HighAutocar Recalls Xpeditor Trucks for Fuel Hose Separation Risk
NHTSA · 2026-10-21
- SevereAudi Recalls 2024-2025 Q4 E-Tron Models Due to Battery Fire Risk
NHTSA · 2026-10-21
- HighForest River Recalls 2023-2026 Pause Travel Trailers for Wiring Defect
NHTSA · 2026-10-20
- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
Similar recalls
- SevereNavistar Recalls International Trucks Due to Alternator Cable Fire Risk
NHTSA · 2012-05-02
- High
- SevereNavistar Recalls 2010-2012 International Trucks Due to Fire Risk
NHTSA · 2011-08-17
- HighNavistar Recalls 2016 International Trucks Due to Engine Stalling Risk
NHTSA · 2015-10-08
- SevereNavistar Recalls 2015-2016 International Trucks Due to Brake Fire Risk
NHTSA · 2015-03-23
- HighNavistar Recalls International Buses Due to HVAC Wiring Fire Risk
NHTSA · 2023-04-06