New Flyer Transit Buses Recalled for Transmission Yoke Separation Risk
New Flyer is recalling 2019-2024 transit buses because the transmission yoke may separate, causing a sudden loss of drive power and increasing crash risk.
What this means for you
Illness, injury, or structural failure has been reported. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a structural vehicle defect (transmission yoke separation) that results in a sudden loss of drive power, which the source states can increase the risk of a crash.
Plain-English summary
New Flyer of America, Inc. is recalling certain 2019-2024 XD35, XD40, XN35, and XN40 transit buses. The recall addresses a defect where the transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
A sudden loss of drive power can increase the risk of a crash. The affected vehicles are 2019-2024 model year New Flyer XN40, XN35, XD35, and XD40 buses.
New Flyer will work with Allison Transmission Inc. to inspect and, if necessary, tighten loose transmission yoke bolts free of charge. Owner notification letters were mailed on December 9, 2023. Owners may contact New Flyer customer service at 1-800-241-2947 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- NEW FLYER XN40, XN35, XD35, XD40
- Brand
- NEW FLYER
- Manufacturer
- New Flyer of America, Inc.
- Category
- Vehicle — Transit Bus
- Hazard
- Affected units
- 2,351
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (4)
- XN40
- XN35
- XD35
- XD40
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · NEW FLYER
- HighNew Flyer Recalls 2022 XE40 Buses for Speedometer Illumination Defect
NHTSA · 2026-05-01
- SevereNew Flyer Recalls Transit Buses Due to Inverter Software Error
NHTSA · 2026-03-13
- SevereNew Flyer Transit Bus Recall for Antilock Braking System Failure
NHTSA · 2025-12-19
- SevereNew Flyer Recalls Transit Buses Due to High Voltage Battery Fire Risk
NHTSA · 2025-09-19
- SevereNew Flyer Recalls Electric Buses Due to Battery Overheating Risk
NHTSA · 2025-08-29
Same manufacturer · New Flyer of America, Inc.
See all →- SevereNew Flyer buses may have too few or misplaced emergency exits
NHTSA · 2025-08-22
- SevereNew Flyer Transit Buses Recalled for Fuel Hose Separation Risk
NHTSA · 2025-02-03
Same hazard · loss of power
See all →- SevereFord Recalls 2026 Explorers Due to Engine Bearing Seizure Risk
NHTSA · 2026-08-13
- SevereBMW Vehicles Recalled Due to Potential Loss of Power and Rollaway Risk
NHTSA · 2026-08-12
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- SevereKTM 390 electronic throttle control may fail after water entry
NHTSA · 2026-03-27
- SevereLucid Air half-shaft may disconnect from the drive unit
NHTSA · 2026-03-26