E-ONE Fire Trucks Recalled for Electronic Stability Control Defect
E-ONE is recalling 2008-2011 Quest, Cyclone II, and Typhoon vehicles because the electronic stability control system may malfunction, increasing crash risk.
What this means for you
Our assessment, not the agency’s: severity 3/5 (High).
Real risk of harm even if no illness or injury has been reported yet. Stop using the product and follow the agency's guidance.
Our severity reasoning: The recall involves a defect in a safety-critical system (Electronic Stability Control) that increases the risk of a crash, but the source text does not report any injuries, fatalities, or specific agency classification that would mandate a higher score.
Plain-English summary
E-ONE, Inc. is recalling certain model year 2008 through 2011 Quest, Cyclone II, and Typhoon vehicles manufactured between May 1, 2008, and November 28, 2011. These vehicles are equipped with Meritor Wabco Electronic Stability Control (ESC) modules. The recall affects 220 units.
Under certain road and driving conditions, vehicle body roll and road inclination may adversely affect the ESC system's slip angle calculation. This may cause the system to incorrectly perceive an over-steering situation and apply the outer front wheel brake until the vehicle is perceived to be stable. If the driver is slow to react to this intervention, the vehicle may deviate from the intended line of travel, increasing the risk of a crash.
E-ONE will notify owners and is working with Meritor Wabco to replace the control module free of charge. The safety recall began on December 16, 2011. Owners may contact E-ONE Customer Service at 1-800-627-5050 or Meritor On Track Customer Service at 1-866-668-7221.
The recalled product
- Product
- E-ONE QUEST, CYCLONE II, TYPHOON
- Brand
- E-ONE
- Manufacturer
- E-ONE, INC.
- Category
- Vehicle — Fire Apparatus
- Affected units
- 220
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (3)
- QUEST
- CYCLONE II
- TYPHOON
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · E-ONE
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls Fire Trucks Due to Hydraulic Valve Defect
NHTSA · 2026-08-19
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- HighE-One Recalls Fire Trucks Due to Engine Crossmember Defect
NHTSA · 2024-10-11
- SevereE-One Recalls Cyclone and Typhoon Vehicles Due to Crossmember Defect
NHTSA · 2024-08-30
Same manufacturer · E-ONE, INC.
See all →- SevereE-One Fire Fighting Chassis Recalled for Exhaust Clamp Failure Risk
NHTSA · 2011-08-17
- HighE-One Fire Fighting Vehicles Recalled for Door Handle Bracket Defect
NHTSA · 2011-07-13
- SevereE-ONE Fire Trucks Recalled for Engine Shutdown Risk
NHTSA · 2010-05-26
- HighE-One Recalls 2009 Fire Trucks Due to Exhaust Switch Failure
NHTSA · 2010-01-06
Same hazard · loss of control
See all →- SevereSubaru Recalls 2026 Forester and Crosstrek for Ball Joint Defect
NHTSA · 2026-10-19
- SeverePorsche Recalls 2024 Models for Center Lock Wheel Bolt Fracture Risk
NHTSA · 2026-10-16
- SevereRing Power Recalls Terex Vehicles Due to Potential Pintle Hitch Failure
NHTSA · 2026-10-02
- SevereATC Recalls RM900 and RM700 Trailers Due to Coupler Bolt Loosening
NHTSA · 2026-09-25
- Severe
Similar recalls
- SevereE-One Recalls 2013-2014 Emergency Vehicles Due to Suspension Defect
NHTSA · 2015-09-24
- HighE-One Recalls 2016-2017 Emergency Vehicles for Steering Defect
NHTSA · 2017-10-09
- Severe
- HighE-One Recalls Cyclone II and Typhoon Vehicles for Electrical Fire Risk
NHTSA · 2016-06-16
- HighE-One Recalls 2013-2014 Fire Fighting Chassis Due to Software Defect
NHTSA · 2014-04-18
- Severe