E-One Fire Trucks Recalled for Electrical Connection Overheating Risk
E-One is recalling specific 2019-2022 fire trucks because a loose electrical connection may cause the load center to overheat, increasing fire risk.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a structural vehicle defect (electrical connection) that can lead to a fire, which aligns with the 'Severe' criteria for significant injury/property-damage reports or structural defects.
Plain-English summary
E-One Incorporated is recalling certain 2019-2021 Cyclone 2, 2020 Commercial, Quest 2, 2020-2021 Typhoon, 2021 Cyclone N, and 2020-2022 Typhoon N fire trucks. The recall addresses a potential defect in the QO Plug-On Neutral Load Center where the neutral screw connection may be loose.
If the neutral screw connection is loose, the affected load center can overheat. An overheated load center can increase the risk of a fire. No specific injuries or fires are reported in the source text.
Dealers will inspect and repair, or replace the load center, free of charge. Owner notification letters were mailed on October 24, 2022. Owners may contact E-One's customer service at 1-352-237-1122 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- E-ONE CYCLONE II, TYPHOON, TYPHOON N, CYCLONE N
- Brand
- E-ONE
- Manufacturer
- E-One Incorporated
- Category
- Vehicle — Fire Trucks
- Affected units
- 78
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (6)
- CYCLONE II
- TYPHOON
- TYPHOON N
- CYCLONE N
- QUEST II
- COMMERCIAL
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · E-ONE
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls Fire Trucks Due to Hydraulic Valve Defect
NHTSA · 2026-08-19
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- HighE-One Recalls Fire Trucks Due to Engine Crossmember Defect
NHTSA · 2024-10-11
- SevereE-One Recalls Cyclone and Typhoon Vehicles Due to Crossmember Defect
NHTSA · 2024-08-30
Same manufacturer · E-One Incorporated
See all →- HighE-One Recalls 2024 Cyclone N and Typhoon N for Suspension Bolt Defect
NHTSA · 2024-07-02
- Severe
Same hazard · fire
See all →- SevereVQQQ Gas Patio Heaters Recalled for Fire and Burn Hazards
CPSC · 2026-10-22
- SevereAudi Recalls 2024-2025 Q4 E-Tron Models Due to Battery Fire Risk
NHTSA · 2026-10-21
- HighAutocar Recalls Xpeditor Trucks for Fuel Hose Separation Risk
NHTSA · 2026-10-21
- HighForest River Recalls 2023-2026 Pause Travel Trailers for Wiring Defect
NHTSA · 2026-10-20
- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
Similar recalls
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- SevereE-One Recalls Fire Trucks Due to Electrical Fire Risk
NHTSA · 2024-01-08
- SevereE-One Recalls Typhoon N and Cyclone II Emergency Vehicles for Fire Risk
NHTSA · 2022-11-18
- SevereE-One Recalls Fire Trucks Due to Fuel Tube Cracking Risk
NHTSA · 2021-12-09
- HighE-One Recalls 2022 Fire Trucks Due to Lighting Failure Risk
NHTSA · 2022-05-24
- SevereE-One Emergency Vehicles Recalled for Electrical Fire Risk
NHTSA · 2018-01-09