E-One Recalls 2024 Commercial and Cyclone N Vehicles for Electrical Fire Risk
E-One is recalling 22 model-year 2024 vehicles equipped with specific multiplex nodes due to a firmware defect that can cause electrical circuits to overheat and increase fire risk.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a structural vehicle defect (electrical system) that explicitly increases the risk of fire, meeting the criteria for a Severe rating.
Plain-English summary
E-One Incorporated is recalling certain 2024 Commercial, Cyclone N, Typhoon N, and Typhoon EV vehicles. The recall affects 22 vehicles equipped with Hercules HC 1.7 multiplex nodes.
The defect involves firmware in the multiplex nodes that may fail to shut off the output pin during a short circuit or wiring failure. This failure results in overloaded electrical circuits, which can overheat and increase the risk of fire.
Owner notification letters were mailed on April 5, 2024. Owners should contact E-One customer service at 1-352-237-1122 to schedule a free firmware update. Owners may also contact the NHTSA Vehicle Safety Hotline at 1-888-327-4236 or visit www.nhtsa.gov for more information.
The recalled product
- Product
- E-ONE CYCLONE N, TYPHOON, TYPHOON N, COMMERCIAL
- Brand
- E-ONE
- Manufacturer
- E-One Incorporated
- Category
- Vehicle — Fire Apparatus
- Hazard
- Affected units
- 22
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (4)
- CYCLONE N
- TYPHOON
- TYPHOON N
- COMMERCIAL
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · E-ONE
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls Fire Trucks Due to Hydraulic Valve Defect
NHTSA · 2026-08-19
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- HighE-One Recalls Fire Trucks Due to Engine Crossmember Defect
NHTSA · 2024-10-11
- SevereE-One Recalls Cyclone and Typhoon Vehicles Due to Crossmember Defect
NHTSA · 2024-08-30
Same manufacturer · E-One Incorporated
See all →- HighE-One Recalls 2024 Cyclone N and Typhoon N for Suspension Bolt Defect
NHTSA · 2024-07-02
- SevereE-One Recalls 280 Fire Apparatus Due to Steering Bracket Defect
NHTSA · 2024-01-12
Same hazard · fire
See all →- SevereVQQQ Gas Patio Heaters Recalled for Fire and Burn Hazards
CPSC · 2026-10-22
- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
- SevereAlliance RV Recalls Valor and Delta Trailers Due to Fire Risk
NHTSA · 2026-10-16
- Severe3M Recalls Scotch Thermal Laminators Due to Fire Hazard
CPSC · 2026-10-15
- SevereToyota Recalls Land Cruiser Hybrid Vehicles for Fuel Leak Risk
NHTSA · 2026-10-14
Similar recalls
- SevereE-One Recalls Fire Trucks Due to Electrical Fire Risk
NHTSA · 2024-01-08
- HighE-One Recalls 2022 Fire Trucks Due to Lighting Failure Risk
NHTSA · 2022-05-24
- SevereE-One Recalls Typhoon N and Cyclone II Emergency Vehicles for Fire Risk
NHTSA · 2022-11-18
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- SevereE-One Fire Trucks Recalled for Electrical Connection Overheating Risk
NHTSA · 2022-07-26
- HighE-One Recalls Cyclone II and Typhoon Vehicles for Electrical Fire Risk
NHTSA · 2016-06-16