E-One Recalls Fire Trucks Due to Electrical Fire Risk
E-One is recalling 408 fire trucks because a wiring defect may cause electrical circuits to overheat and start a fire.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a structural vehicle defect (electrical wiring) that explicitly increases the risk of fire, which aligns with the 'Severe' criteria for significant injury/property-damage reports or structural defects.
Plain-English summary
E-One Incorporated is recalling certain 2020-2024 E-One fire trucks, including the Typhoon N, Commercial, Cyclone E, Cyclone N, ARFF, Typhoon, and Cyclone II models. The recall covers 408 vehicles in total.
The defect involves the vehicle's multiplex system firmware. In the event of a short circuit or wiring failure, the firmware may fail to shut off the output pin. This results in overloaded electrical circuits that can overheat, increasing the risk of fire.
Weldon, the equipment manufacturer, will update the firmware free of charge to correct the issue. Owner notification letters were mailed on January 24, 2024. Owners may contact E-One customer service at 1-352-237-1122 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- E-ONE TYPHOON N, COMMERCIAL, CYCLONE E, CYCLONE N
- Brand
- E-ONE
- Manufacturer
- E-One Incorporated
- Hazard
- Affected units
- 408
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (7)
- TYPHOON N
- COMMERCIAL
- CYCLONE E
- CYCLONE N
- ARFF
- TYPHOON
- CYCLONE II
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · E-ONE
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls Fire Trucks Due to Hydraulic Valve Defect
NHTSA · 2026-08-19
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- HighE-One Recalls Fire Trucks Due to Engine Crossmember Defect
NHTSA · 2024-10-11
- SevereE-One Recalls Cyclone and Typhoon Vehicles Due to Crossmember Defect
NHTSA · 2024-08-30
Same manufacturer · E-One Incorporated
See all →- HighE-One Recalls 2024 Cyclone N and Typhoon N for Suspension Bolt Defect
NHTSA · 2024-07-02
- Severe
Same hazard · fire
See all →- SevereVQQQ Gas Patio Heaters Recalled for Fire and Burn Hazards
CPSC · 2026-10-22
- SevereAlliance RV Recalls Valor and Delta Trailers Due to Fire Risk
NHTSA · 2026-10-16
- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
- Severe3M Recalls Scotch Thermal Laminators Due to Fire Hazard
CPSC · 2026-10-15
- SevereToyota Recalls Land Cruiser Hybrid Vehicles for Fuel Leak Risk
NHTSA · 2026-10-14
Similar recalls
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- SevereE-One Fire Trucks Recalled for Electrical Connection Overheating Risk
NHTSA · 2022-07-26
- Severe
- HighE-One Recalls 2022 Fire Trucks Due to Lighting Failure Risk
NHTSA · 2022-05-24
- SevereE-One Recalls Typhoon N and Cyclone II Emergency Vehicles for Fire Risk
NHTSA · 2022-11-18
- SevereE-One Recalls Fire Trucks Due to Fuel Tube Cracking Risk
NHTSA · 2021-12-09