E-One Fire Apparatus Recalled for Fuel Rail Leak Fire Risk
E-One Incorporated is recalling 2017-2021 fire apparatus vehicles because a defective sealing washer may cause a fuel leak, increasing the risk of fire.
What this means for you
Our assessment, not the agency’s: severity 4/5 (Severe).
The hazard poses a serious risk of illness, injury, or structural failure. Stop using the product immediately and contact the manufacturer for a refund or repair.
Our severity reasoning: The recall involves a fuel leak that increases the risk of fire, which constitutes a significant injury/property-damage report criterion under the rubric for vehicle defects.
Plain-English summary
E-One Incorporated is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The recall involves 915 units where the sealing washer may not seat correctly in the pilot bore holes. This defect allows the high-pressure fuel rail assembly to leak.
A fuel leak in the presence of an ignition source increases the risk of a fire. No specific injuries or fatalities are reported in the source text, but the hazard presents a significant safety risk due to the potential for fire.
Dealers will inspect and replace the fuel rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- E-ONE TYPHOON N, CYCLONE II, QUEST II, TYPHOON
- Brand
- E-ONE
- Manufacturer
- E-One Incorporated
- Category
- Vehicle — Fire Apparatus
- Affected units
- 915
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (5)
- TYPHOON N
- CYCLONE II
- QUEST II
- TYPHOON
- CYCLONE N
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · E-ONE
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls Fire Trucks Due to Hydraulic Valve Defect
NHTSA · 2026-08-19
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- HighE-One Recalls Fire Trucks Due to Engine Crossmember Defect
NHTSA · 2024-10-11
- SevereE-One Recalls Cyclone and Typhoon Vehicles Due to Crossmember Defect
NHTSA · 2024-08-30
Same manufacturer · E-One Incorporated
See all →- HighE-One Recalls 2024 Cyclone N and Typhoon N for Suspension Bolt Defect
NHTSA · 2024-07-02
- Severe
Same hazard · fire
See all →- SevereVQQQ Gas Patio Heaters Recalled for Fire and Burn Hazards
CPSC · 2026-10-22
- SevereAudi Recalls 2024-2025 Q4 E-Tron Models Due to Battery Fire Risk
NHTSA · 2026-10-21
- HighAutocar Recalls Xpeditor Trucks for Fuel Hose Separation Risk
NHTSA · 2026-10-21
- HighForest River Recalls 2023-2026 Pause Travel Trailers for Wiring Defect
NHTSA · 2026-10-20
- SevereForest River Recalls 2026-2027 Cedar Creek Trailers for Fire Risk
NHTSA · 2026-10-16
Similar recalls
- SevereE-One Recalls Fire Trucks Due to Fuel Tube Cracking Risk
NHTSA · 2021-12-09
- SevereE-One Recalls Typhoon N and Cyclone II Emergency Vehicles for Fire Risk
NHTSA · 2022-11-18
- SevereE-One Recalls Fire Trucks Due to Electrical Fire Risk
NHTSA · 2024-01-08
- SevereE-One Recalls Fire Trucks Due to Wiring Overheat Risk
NHTSA · 2026-10-06
- HighE-One Recalls 2022 Fire Trucks Due to Lighting Failure Risk
NHTSA · 2022-05-24
- SevereE-One Fire Trucks Recalled for Electrical Connection Overheating Risk
NHTSA · 2022-07-26