Hyundai Recalls Sonata Plug-In Hybrids for Voltage Protection Device Defect
Hyundai is recalling 2016-2018 Sonata Plug-In Hybrids because a voltage protection device may activate inadvertently, causing loss of power and increasing crash risk.
What this means for you
Real risk of harm even if no illness or injury has been reported yet. Stop using the product and follow the agency's guidance.
Our severity reasoning: The recall involves a risk-of-harm product where a loss of power increases the risk of a crash, but no injuries or fatalities are reported in the source text.
Plain-English summary
Hyundai Motor America is recalling certain 2016-2018 Hyundai Sonata Plug-In Hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD) designed to protect the high voltage battery module, but the device may activate inadvertently.
If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, which increases the risk of a crash. The recall is expected to begin in May 2018.
Hyundai will notify owners, and dealers will remove the VPD switch and install a new Battery Management System (BMS) that contains an Overvoltage Protection Device (OPD). Owners may contact Hyundai customer service at 1-855-371-9460 or the NHTSA Vehicle Safety Hotline at 1-888-327-4236.
The recalled product
- Product
- HYUNDAI SONATA PLUG-IN HYBRID
- Brand
- HYUNDAI
- Manufacturer
- Hyundai Motor America
- Hazard
- Affected units
- 2,840
Is your product affected?
Check your packaging against the codes below. If any of them match, the product is part of this recall.
Model numbers (1)
- SONATA PLUG-IN HYBRID
Distribution
Distributed nationwide across the United States.
Related recalls
Same brand · HYUNDAI
- High2026 Hyundai Kona rear center seat belt buckle failure risk
NHTSA · 2026-07-14
- SevereHyundai Recalls 2023-2024 Ioniq 5 Vehicles Due to Battery Fire Risk
NHTSA · 2026-07-02
- HighHyundai Tucson instrument panel displays may fail due to software error
NHTSA · 2026-06-23
- SevereHyundai Ioniq rear suspension fasteners may loosen and detach
NHTSA · 2026-05-18
- High2025–2026 Hyundai Tucson and Santa Cruz Front Camera Software Issue
NHTSA · 2026-05-18
Same manufacturer · Hyundai Motor America
See all →- SevereGenesis Recalls 2027 G80 Vehicles for Ignition Coil Ground Bolt Issue
NHTSA · 2026-07-29
- HighHyundai Elantra Hybrid power control units may overheat
NHTSA · 2026-05-14
Same hazard · loss of power
See all →- SevereFord Recalls 2026 Explorers Due to Engine Bearing Seizure Risk
NHTSA · 2026-08-13
- SevereBMW Vehicles Recalled Due to Potential Loss of Power and Rollaway Risk
NHTSA · 2026-08-12
- SevereE-One Recalls Emergency Vehicles Due to Drive Mode Transfer Case Defect
NHTSA · 2026-07-15
- SevereKTM 390 electronic throttle control may fail after water entry
NHTSA · 2026-03-27
- SevereLucid Air half-shaft may disconnect from the drive unit
NHTSA · 2026-03-26