Severity 4 of 5
Illness, injury, or structural failure has been reported. Stop using the product immediately and contact the manufacturer for a refund or repair.
Severity 4 (Severe) recalls have a real, documented risk of significant injury, hospitalization, or property damage even if no deaths have been reported. The agency classification is FDA Class II with hospitalization reports, USDA Class I, or a structural vehicle defect. These need attention quickly — not five-alarm urgency but not something to put off. Examples include allergen mislabeling on common allergens for products eaten by children, drug potency out of specification by a margin that could cause measurable harm, and vehicle defects affecting braking or steering.
The full rubric is on the methodology page. Severity is computed deterministically from the agency’s own classification plus the source text — no editorial vibes.
New Flyer is recalling 2019-2025 XE35, XE40, and XE60 transit buses because a high voltage battery short circuit may cause a fire. Owners should park outside and limit charging to 75%.
Motor Coach Industries is recalling specific 2024 and 2025 electric coaches because a high-voltage battery short circuit could cause a fire.
About 22,600 IcyBreeze Buddy portable misting fans are recalled because the fan can overheat while charging and ignite. Seven overheating reports include two that resulted in fire; no injuries.
About 21,690 Ambiano cotton candy makers, model 836098, are recalled because the heating element can ignite sugar if used without the sugar receptacle. Twelve sparking or fire reports; no injuries.
General Motors is recalling certain Cadillac Escalade, Chevrolet Tahoe and GMC Yukon diesel vehicles because the original fuel tank may have been replaced with an incorrect tank that can leak in a rollover.
Ford is recalling 2023-2024 Transit vehicles previously repaired under recalls 24V226 and 24V591 due to potential installation of incorrect steering coupler covers and tires.
Hyundai is recalling certain 2023-2025 Genesis GV60 electric vehicles because the stainless-steel molding at the top of the windshield assembly may detach.
About 66,000 tabletop fire pits sold at Five Below are recalled because alcohol fuel can splash or leak during use or ignition, causing a flash fire. One report of flames escaping; no injuries.
ZF North America is recalling manual transmissions with an insufficient weld that may cause fluid leaks and loss of drive power or park function.
Quality Poultry & Seafood, Inc. is recalling approximately 98,916 pounds of catfish fillet products produced without federal inspection. The products were distributed to restaurants and retail locations in Alabama, Mississippi, and Louisiana.
Ford is recalling 2015-2017 Mustangs because water and road salt may corrode front seat belt anchor pretensioner cables, increasing injury risk in a crash.
Daimler Vans USA is recalling 2024 Mercedes-Benz Sprinter 2500 and 3500 vehicles because longitudinal frame members may not be reinforced properly, potentially reducing crash performance.
Ford is recalling 2016-2019 Taurus vehicles because the B-pillar door trim may detach while driving, creating a road hazard and increasing crash risk.
Forest River is recalling certain 2025-2026 Spirit and Shasta Oasis recreational trailers because the 30 or 50 amp inlet wire sheathing may be inconsistently stripped, causing electrical arcing. 502 units are affected.
Daimler Trucks North America is recalling certain 2025-2026 Thomas Built Buses school buses because improperly installed steering fasteners may cause a loss of steering control.
KTM North America is recalling certain Husqvarna Svartpilen 401, Vitpilen 401 and KTM 390 Adventure motorcycles because water could enter the e-throttle control unit and cause loss of drive power. 9,070 units are affected.
Daimler Trucks North America is recalling 2025-2026 Thomas Built Buses Saf-T-Liner C2 and Jouley models because brake caliper bolts may loosen, risking brake failure.
Daimler Trucks North America is recalling certain Freightliner, Western Star, FCCC and Thomas Built vehicles because the tie rod castle nut and cotter pin may be improperly installed. 343 units are affected.
Ford is recalling certain 2024 Bronco and Ranger vehicles because the bolts securing the high pressure fuel pump may not be tightened properly, which can result in a fuel leak. 9 units are affected.
Micro Bird is recalling 2023-2025 G5 buses because door attachment rings may delaminate, causing doors to open unexpectedly and risking passenger injury.
Daimler Trucks North America is recalling a range of Freightliner, Western Star and FCCC vehicles over brake caliper mounting bolts, which can lead to a loss of brake function. 402 units are affected.
Hyundai is recalling certain 2025 IONIQ 5 electric vehicles because rear suspension alignment adjustment bolts may have been improperly tightened, which can cause a loss of vehicle stability control. 8 units are affected.
About 110,000 Paris Hilton Mini Beauty Fridges are recalled because the electrical switch can short circuit and overheat. The firm has 27 reports of the fridge overheating and catching fire, with property damage.
Hyundai is recalling certain 2020-2025 Palisade vehicles because the driver, passenger and second-row window seat belt buckles may fail to latch. 568,580 units are affected.
Chrysler is recalling 2018 Ram 1500, 2500, and 3500 vehicles because side curtain air bag inflators may rupture, potentially causing injury from metal fragments.